油氣回收系統分段介紹

　　Segmented introduction of oil and gas recovery system

　?。?）卸油油氣回收系統（一次回收）

　　(1) Unloading oil and gas recovery system (primary recovery)

　　定義：將汽油油罐車卸油時產生的油氣回收至油罐車里的密閉油氣回收系統。

　　Definition: A closed oil and gas recovery system that recovers the oil and gas generated during the unloading of gasoline tank trucks into the tank trucks.

　　通過卸油油氣回收管線連接

　　Connect through unloading oil and gas recovery pipelines

　?、購挠推沸盾圏c埋地敷設一根油氣回收主管線與加油站的所有汽油儲油罐的氣相管道連通，油氣回收管線卸車側安裝截流閥、密封式快速接頭和帽蓋；

　?、?Lay an oil and gas recovery main pipeline underground from the oil unloading point and connect it to the gas phase pipelines of all gasoline storage tanks at the gas station. Install a shut-off valve, sealed quick connector, and cap on the unloading side of the oil and gas recovery pipeline;

　　②汽油油罐內部卸車管安裝防溢油閥。

　?、?Install an anti overflow valve on the unloading pipe inside the gasoline tank.

　　③從其中一個汽油油罐出來一根通氣管在地上部分匯總為兩根通氣管。一根安裝球閥、頂部安裝一個機械呼吸閥；一根安裝球閥、頂部安裝一個防雨型阻火器。

　　③ A vent pipe coming out of one of the gasoline tanks is combined into two vent pipes on the ground. Install a ball valve and a mechanical breathing valve on the top; Install a ball valve and a rainproof flame arrester on the top.

　?。?）加油油氣回收系統（二次回收）

　　(2) Refueling oil and gas recovery system (secondary recovery)

　　定義：將給汽車油箱加汽油時產生的油氣，通過密閉方式收集進入埋地油罐的系統（也稱為二階段油氣回收）。

　　Definition: A system (also known as two-stage oil and gas recovery) that collects the oil and gas generated when adding gasoline to a car's fuel tank in a closed manner and enters a buried oil tank.

　　a）分散式回收系統

　　a) Distributed recycling system

　　分散式的真空泵一般分別設置于各臺加油機內，通常采用渦輪葉片式真空泵連結一條與輸油管平行的油氣回收管線和地下儲油罐連結。當油品輸出 時電機帶動渦輪葉片式真空泵產生真空，進而通過回收油槍達到回收車輛油箱內揮發油氣的效果。

　　Distributed vacuum pumps are generally installed separately in each refueling machine, usually using turbine blade vacuum pumps to connect an oil and gas recovery pipeline parallel to the oil pipeline and an underground oil storage tank. When the oil is output, the motor drives the turbine blade vacuum pump to generate vacuum, which then recovers the volatile oil and gas in the vehicle's fuel tank through the oil recovery gun.

　　從各汽油加油機敷設加油油氣回收埋地管線，并匯總為一根管線至低標號汽油儲罐，與其氣相連接。

　　Lay buried pipelines for refueling oil and gas recovery from various gasoline dispensers, and consolidate them into one pipeline to connect with low-grade gasoline storage tanks.

　　b）集中式回收系統

　　b) Centralized recycling system

　　集中式的真空泵設置于油氣回收管與地下儲油罐連接處，一般每個地下儲油罐設置1臺中央吸取式真空泵，從各汽油加油機敷設加油油氣回收埋地管線，并匯總為一根管線經集中式真空泵至低標號汽油儲罐，與其氣相連接。

　　A centralized vacuum pump is installed at the connection between the oil and gas recovery pipe and the underground oil storage tank. Generally, each underground oil storage tank is equipped with one central suction vacuum pump. The buried pipeline for refueling oil and gas recovery is laid from each gasoline refueling machine and summarized into one pipeline, which is connected to the low-grade gasoline storage tank through the centralized vacuum pump and connected to its gas phase.

　?。?）油氣排放處理裝置（三次回收）

　　(3) Oil and gas emission treatment device (tertiary recovery)

　　定義：針對加油油氣回收系統部分排放的油氣，通過采用吸附、吸收、冷凝、膜分離等方法對這部分排放的油氣進行回收處理的裝置。

　　Definition: A device that uses adsorption, absorption, condensation, membrane separation, and other methods to recover and treat the partially discharged oil and gas from the refueling oil and gas recovery system.

　　油氣回收裝置（三次回收）的安裝及相應的電纜敷設、控制器安裝。油氣回收裝置（三次回收）入口管線與高標號汽油油罐氣相連接，出口管線及凝液回流管線與低標號汽油儲罐氣相連接。

　　Installation of oil and gas recovery device (tertiary recovery) and corresponding cable laying, controller installation. The inlet pipeline of the oil and gas recovery device (tertiary recovery) is connected to the high-grade gasoline tank gas, and the outlet pipeline and condensate reflux pipeline are connected to the low-grade gasoline tank gas.

　　本文由 油氣回收設備  友情奉獻.更多有關的知識請點擊  http://www.wmjdwx.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from oil and gas recovery equipment For more related knowledge, please click http://www.wmjdwx.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.